6x4 Gator is overheating.... help! - Green Tractor Talk
2019年1月1日 · Good Morning having a few issues with my new-to-me 2003 6x4 Gator. Its overheating after driving it a short distance. A good friend helped me with it yesterday, and we were able to answer a few questions, but now seems to be even more puzzled? So, here goes... The Gator's red temp light on the dash comes on after its been driven just a short while.
1996 John Deere Gator 6x4 - Engine Problems
2019年5月24日 · I have lovingly restored this older 6x4 but am having some issues with the engine. I am a weekend warrior and a massive tinkerer. I can usually fix anything if pointed in the right direction. I recently changed the spark plugs, carburetor and fuel pump. Built on 12/7/94 PC2387 SERIAL #W006X-4X011774 ENGINE #FD620D-056404
6 x 4 braking problem - John Deere Gator Forums
2012年6月30日 · On the 6x4 and some others, the brakes are inside the transmission. They are of the wet type and actuate with what is known as a ramp and ball system. There are a couple solutions to reduce or eliminate the growl, chatter, grind.
No spark to JD Gator 6 x 4 - help? - Green Tractor Talk
2019年8月16日 · Here's what little info I can provide: Engine cranks strong but it won't fire. Fuel pump is engaging, filter seems fine. Tested at plugs and problem seems to be no spark at EITHER cylinder. We put a tester on the plug end and cranked engine and nothing. Pulled leads off what we think is the primary coil (not sure) and used volt meter.
john deer 6x4 with fd620d engine - My Tractor Forum
2021年12月9日 · I have some issues with the fd620d engine in a 6x4 gator. done a complete rebuild on it new pistons, rings, valve seal, new cam and all new gaskets. my problem is that it's great idles fine motor sounds great amd does what it supossed to do when I shut it down. when I put it under a load driving it around and then stop and shut it off it ...
Troubleshooting - John Deere
If you are experiencing a problem that is not listed in this chart, see your John Deere dealer for service. When you have checked all the possible causes listed and you are still experiencing the problem, see your John Deere dealer. · Battery has low voltage. · Loose or corroded battery connections. · Fusible link is melted.
John Deere TH 6x4 Gator loss of power. - My Tractor Forum
2021年11月4日 · Number 1 is a compression and preferably a leak down test. That will give you an indication of the health of the valves and rings. The complete fuel system should be thoroughly cleaned, from tank to engine, including the carburetor. The gas/diesel mix was syphoned out and that was all that was done.
Gator 6x4 Overheating problem - Utility Vehicles UTV/ATV
2017年4月5日 · The next annual dealer service included their fix for the OVERHEATING PROBLEM. They changed the thermostat and replaced the water pump. That did not fix the problem. I took the machine back to them and the fix this time was: COULD NOT DUPLICATE THE PROBLEM. After reading some on line fixes, I tried the air relief at …
6x4 Diesel with Fuel Issues | John Deere Gator Forums
2017年6月20日 · Looking for ideas: Was running great then stopped dead would not restart. Found no fuel flow. Replaced fuel pump, all fuel lines running into and out of tank, including new fuel tank rod with screen attached, new fuel filter. Now getting fuel and motor starts and idles fine.
6X4 Diesel Gator, Issue - Green Tractor Talk
2018年1月14日 · Perhaps you have a bad switch or some bad wiring with an exposed or grounded connection. 2720 w/ 200CX FEL, Ken's weld-on hooks, Fit Rite Hydraulics Top and Tilt kit, Artillian forks. Dieselshadow is my Hero. Replaced temp sending unit. Have checked it with temp gauge (gun) and Like I stated don't have that Documentation handy,